Jump to content

Lithium-titanate battery

From Wikipedia, the free encyclopedia
lithium-titanate battery
Specific energy60–110Wh/kg[1]
Energy density177–202Wh/L[1],[2]
Cycle durability6000–+45000cycles,[1][3]
Nominal cell voltage2.3V[1]

Thelithium-titanateorlithium-titanium-oxide (LTO) batteryis a type ofrechargeable batterywhich has the advantage of being faster to charge[4]than otherlithium-ion batteriesbut the disadvantage is a much lowerenergy density.

Uses

[edit]

Titanate batteries are used in certain Japanese-only versions ofMitsubishi'si-MiEV[5]electric vehicleas well asHonda's EV-neo electric bike andFit EV.[6][7]They are also used in theTosaconcept electric bus.[8]Because of the battery's high level of safety and recharge capabilities, LTO batteries are used in car audio applications as well as mobile medical devices.[9]

An LTO battery is also used in theS-Penthat comes with theSamsungGalaxy Note 20 Ultra 5G.[10]

According to a Weatherflow Co. article,[11]the Tempest weather-station device contains a 1300 mAh LTO battery, charged via four solar panels, requiring "at least 4 hours of adequate sunlight every two weeks."

The Combustion Predictive Thermometer is described as using an LTO battery. According to Combustion Inc., this allows it to safely survive temperatures up to 105 °C (221 °F) inside of ovens.[12]

Chemistry

[edit]

Alithium-titanatebattery is a modified lithium-ion battery that uses lithium-titanate nanocrystals, instead ofcarbon,on the surface of itsanode.This gives the anode a surface area of about 100 square meters per gram, compared with 3 square meters per gram for carbon, allowing electrons to enter and leave the anode quickly. Also, the redox potential of Li+ intercalation into titanium oxides is more positive than that of Li+ intercalation into graphite. This leads to fast charging (higher charging current) being much safer in the case of the titanate, than in the case of carbon, since lithium dendrites are less likely to form in the former case.[13]Lithium-titanate cells last for 3000 to 7000 charge cycles;[14]a life cycle of ~1000 cycles before reaching 80% capacity is possible when charged and discharged at 55 °C (131 °F), rather than the standard 25 °C (77 °F).[15]

A disadvantage of lithium-titanate batteries is their lower inherent voltage (2.4 V), which leads to a lowerspecific energy(about 30–110 Wh/kg[1]) than conventional lithium-ion battery technologies, which have an inherent voltage of 3.7 V.[16]Some lithium-titanate batteries, however, have anvolumetric energy densityof up to 177 Wh/L.[1]

Brands and uses

[edit]

Log 9 scientific materials

[edit]

The Log9 company is working to introduce its tropicalized-ion battery (TiB) backed by lithium ferro-phosphate (LFP) and lithium-titanium-oxide (LTO) battery chemistries. Unlike LFP and LTO, the more popular NMC (Nickel Manganese Cobalt) chemistry does have the requisite temperature resilience to survive in the warmest conditions such as in India. LTO is not only temperature resilient, but also has a long life.[17]

Altairnano

[edit]

Altairnanoproduces lithium-titanate batteries under the "Nanosafe" line, mainly forbattery electric vehicles.Vehicle manufacturers that have announced plans to use Altairnano batteries includeLightning Car Company,which plans to use them for theLightning GT,an electric sports car;[18][19]Phoenix Motorcars,for use in its electric sport-utility vehicles;[20]and inProterra,its electricEcoRide BE35lightweight 35-foot bus.[21]

Altairnano has also deployed their lithium-titanate energy storage systems for electric grid ancillary services[22]as well as military applications.[23]

Grinergy

[edit]

Grinergy is a South Korean battery manufacturer founded in 2017. It offers commercial and Warfighter military grade LTO battery technology.[24]Grinergy is a 2023 CES Innovation Honoree[25]

Leclanché

[edit]

Leclanchéis a Swiss battery manufacturer founded in 1909. In 2006, it acquired Bullith AG (Germany) to establish a Li-Ion manufacturing line in Germany. In 2014, their product "TiBox" entered the market. The energy content of the TiBox is 3.2 kWh, with an expected 15,000 cycle life span.[26]

Microvast

[edit]

Microvast,based in Houston, Texas, makes a lithium-titanate battery that it calls "LpTO". In 2011, the world's first ultrafast charge bus fleet was launched inChongqing,China. An 80 kWh LpTO battery system was installed in 37 twelve-meter electric buses, which can be fully charged within 10 minutes with a 400 kW charger.[27]

As of 2014, a British bus OEM,Wrightbus,began using Microvast LpTO batteries for 1,000 units of double-deckerNew Routemasterbuses.[citation needed]An 18 kWh LpTO battery system is used to replace the initial Lithium Iron Phosphate battery because the LFP battery encountered performance failure.

As of 2015, the European ZeEUS (zero emission urban transport system) was first offered. Its VDL bus uses a 62.5 kWh LpTO battery system from Microvast[28]for a demonstration project.

As of 2016, the world's largest automated port, PSA TUAS, began using the Microvast LpTO for 22 electric AGVs as a first phase of a project for horizontal container transportation.[29]

Samsung

[edit]

TheBluetooth-enabled S-Pen in theSamsungGalaxy Note10 and 10+ contains a lithium-titanate battery which has a stand-by time of ten hours.[30]

Seiko

[edit]

Seikouses lithium-titanate batteries in its Kinetic (automatic quartz) wristwatches. Earlier Kinetic watches used acapacitorto store energy, but the battery provides a larger capacity and a longer service life. A technician can easily replace the battery when its capacity eventually deteriorates to an unacceptable level.[31]

Stadler

[edit]

TheBritish Rail Class 93tri-mode locomotives built byStadler Railuse lithium-titanate batteries to allow the train to run on unelectrified lines. These liquid cooled cells can be charged while under the overhead lines, or from the onboard diesel engine when the full output isn't needed for traction.[32][33]

Toshiba

[edit]
An example of a SCiB battery

In 2007,Toshibareleased a lithium-titanate battery, dubbed "Super Charge Ion Battery" (SCiB).[34][35]The battery is designed to offer 90% charge capacity in ten minutes.[36]

SCiB batteries are used in theSchwinnTailwind electric bike.[37]Toshiba has also demonstrated its use as aprototypelaptop battery.[38]Toshiba SCiB batteries are used in a Japan-only version ofMitsubishi'si-MiEVandMinicab MiEV[5]electric vehicles,andHondauses them in its EV-neo electric bike andFit EV,which came to market in the summer of 2012.[6][7]JR Central'sN700S Shinkansenuses SCiB batteries to operate at low speed in the event of a disruption to overhead power.[39]

The Toshiba lithium-titanate battery is low voltage (2.3 nominal voltage), with low energy density (between the lead-acid and lithium ion phosphate), but has extreme longevity, charge/discharge capabilities and a wide range operating temperatures.

In 2024, Toshiba specified an expected life of 45,000 cycles at 10C for its "high power" 2.9 Ah SCiB cell,[3]and 20,000 cycles at 3C for its "high energy" 23 Ah cell.[2]At some loss in expected cycle life, these cells can be charged extremely rapidly from 0% to 80% of capacity: in 1 minute (i.e. at 48C) for the 2.9 Ah cell, and in 6 minutes (i.e. at 8C) for the 23 Ah cell. In April 2024, fourSiemens Mireo Plus Bbattery-electric trains were placed into service, powered by Toshiba LTO cells with an expected service life of 15 years.[40]

YABO

[edit]

YABO Power Technology released a lithium-titanate battery in 2012. The standard model YB-LITE2344 2.4 V/15 Ah battery cell has been used in electric vehicle and energy storage systems.[41]

Yinlong Energy

[edit]

Greeintroduced its Yinlong Battery Technology, a type of fast-charging LTO (lithium-titanate) battery, which can operate in extreme temperature conditions. The batteries have an operational life-span up to 10 years. Yinlong Energy provides batteries for such uses as automobiles and energy storage.[42]

See also

[edit]

References

[edit]
  1. ^abcdef"All About Batteries, Part 12: Lithium Titanate (LTO)".EETimes.2015.Retrieved3 July2024.
  2. ^abToshiba."High energy type cells".Retrieved3 July2024.
  3. ^abToshiba."High power type cells".Retrieved3 July2024.
  4. ^Yang, Xiao-Guang; Zhang, Guangsheng; Ge, Shanhai; Wang, Chao-Yang (10 July 2018)."Fast charging of lithium-ion batteries at all temperatures".Proceedings of the National Academy of Sciences.115(28): 7266–7271.Bibcode:2018PNAS..115.7266Y.doi:10.1073/pnas.1807115115.PMC6048525.PMID29941558.
  5. ^ab"Mitsubishi Chooses Super-Efficient Toshiba SCiB Battery For EVs".Integrity Exports. 2011-06-18.Retrieved2011-06-18.
  6. ^ab"Toshiba's SCiB battery for the Fit EV".Green Car Congress. Nov 17, 2011.
  7. ^ab"Honda begins European demonstration program of EV-neo electric scooter".Green Car Congress. Jun 15, 2011.
  8. ^TOSA2013Archived2014-05-25 at theWayback Machine:The project aims to introduce a new system of mass transport with electric "flash" recharging of the buses at selected stops.
  9. ^"All About Batteries, Part 12: Lithium Titanate (LTO)".
  10. ^"Specs | Samsung Galaxy Note20 & Note20 Ultra".The Official Samsung Galaxy Site.Retrieved2020-08-06.
  11. ^"Solar Power for Tempest".help.weatherflow.com.Retrieved2020-08-23.
  12. ^"FAQ".Combustion Inc.Retrieved2023-05-21.
  13. ^Graham-Rowe, Duncan (7 March 2005)."Charge a battery in just six minutes".New Scientist. Archived fromthe originalon 15 October 2008.Retrieved2010-07-06.
  14. ^"LTO Batteries".
  15. ^Han, Xuebing; Ouyang, Minggao; Lu, Languang; Li, Jianqiu (30 July 2014)."Cycle Life of Commercial Lithium-Ion Batteries with Lithium Titanium Oxide Anodes in Electric Vehicles".Energies.7(8): 4895–4909.doi:10.3390/en7084895.
  16. ^"Green Car Congress: Toshiba Developing 3.0 Ah High Power SCiB Li-Ion Cell for HEV Applications".21 May 2008.Retrieved2010-07-07.
  17. ^Startup’s ‘Made-in-India’ Li-Ion Battery Cells for EVs Can End Foreign Imports
  18. ^Page, Lewis (2008-07-22)."Blighty's electro-supercar 2.0 uncloaked today".The Register.Retrieved2008-07-22.
  19. ^"Welcome to Lightning Car Company".Archived fromthe originalon May 26, 2010.Retrieved2010-07-07.
  20. ^"The All-New Phoenix SUV".Phoenix Motorcars. Archived fromthe originalon July 29, 2010.Retrieved2010-07-07.
  21. ^"Proterra – Cost effective solutions for clean transportation".Proterraonline.com. Archived fromthe originalon March 1, 2009.Retrieved2010-07-06.
  22. ^"Altair Nanotechnologies Announces Successful PJM Market Acceptance of the First Grid-Scale, Battery Energy Storage System"(Press release). Altair Nanotechnologies. 2008-11-21. Archived fromthe originalon 2011-07-26.Retrieved2010-07-06.
  23. ^"Altair Nanotechnologies Power Partner – The Military"(Press release). Altair Nanotechnologies. Archived fromthe originalon 2011-07-16.Retrieved2010-07-06.
  24. ^"South Korea Grinergy Looks to U.S. to Grow Battery Technology Operation".
  25. ^"Grinergy Wins CES Innovation Award in the Sustainability, Eco-Design & Smart Energy Category".
  26. ^"Leclanché SA: Leclanché announces the launch of the Ti-Box".eqs-news.com(Press release).Retrieved2024-08-22.
  27. ^China, ChargedEVS (17 June 2012)."Microvast: World's fastest EV charging station goes into service – in China".www.chargedevs.com.Retrieved2012-06-17.
  28. ^Munster Germany, VDL Bus Coach."VDL: 5 VDL Citeas Electric for Stadtwerke Münster to deliver 5 ultrafast charge buses to Germany".vdlbuscoach.com.Archived fromthe originalon 2018-07-18.Retrieved2015-05-01.
  29. ^Singapore, PSA Singapore."PSA Singapore buys 22 AGVs".www.container-mag.com.Retrieved2016-06-21.
  30. ^Samsung Galaxy Note10 and Note10+ hands-on review - GSMArena.com tests
  31. ^"The Seiko Kinetic: Boon or Bane? - Quartzimodo's Time Journal".Quartzimodo's Time Journal.Retrieved2018-06-26.
  32. ^Shirres, David (1 September 2020)."Re-engineering Rail Freight".Rail Engineer.Coalville: Rail Media Group.
  33. ^Richard Clinnick (14 Jan 2021)."Rail Operations (UK) Ltd orders Class 93 tri-modes".Rail Magazine.Retrieved12 February2021.
  34. ^Kouji Kariatsumari (Dec 12, 2007)."Toshiba's New Secondary Battery Squashed... No Explosion, Fire... Why?".Nikkei Electronics.Retrieved2010-07-07.
  35. ^"TOSHIBA – Rechargeable battery SCiB".Retrieved2010-07-07.
  36. ^Aharon Etengoff (Oct 2, 2008)."Toshiba unveils new battery prototype".PC Authority.Retrieved2010-07-07.
  37. ^"Schwinn Electric Bikes".Schwinn Tailwind electric. Archived fromthe originalon 2008-09-29.Retrieved2010-07-07.
  38. ^Sumner Lemo (September 30, 2008)."Toshiba shows prototype fast-charging laptop battery".InfoWorld.Retrieved2010-07-07.
  39. ^Nick Kingsley (2019-10-30)."'Earthquake mode' battery packs to be fitted to N700S Shinkansen fleet ".Railway Gazette International.Retrieved2019-12-04.
  40. ^Batteries instead of diesel – first trains in passenger service in Ortenau,https://www.urban-transport-magazine.com/en/batterie-statt-diesel-die-ersten-zuege-nehmen-in-der-ortenau-den-fahrgastbetrieb-auf/,available 3 July 2024; see alsoNeue Batteriezüge mit Spezialakku - Jochen Steinbauer (Siemens Mobility) & Tobias Beckers (HLB)onYouTube,Batteriepodcast (Karlsruher Institut für Technologie), uploaded 2024-04-14
  41. ^"Advantages of the Lithium Titanate Battery".Knowledge Base.2014-09-19.Retrieved2018-06-26.
  42. ^"Yinlong Energy | Clean Energy & Transportation Solutions".www.yinlong.energy.Retrieved2022-11-19.
Retrieved from "https://en.wikipedia.org/w/index.php?title=Lithium-titanate_battery&oldid=1241742381"